Product ID:5007, CARB-CARE AEROSOL
MSDS Date:11/12/1985
FSC:6850
NIIN:00N032371
MSDS Number: BNQZV

NATIONAL CHEMSEARCH DIV OF NCH CORP

IRVING, TX 75015
US

Emergency Phone: 214-438-4144

Info Phone: 214-438-0401

Preparer: KEVIN UHL

Cage: DO481

NCH CORP

152170 IRVING, TX 75015-2170 US

Telephone: 972-438-0563

Cage: 20913

(ORAL,RAT) 13 GM/KG.

CAS: 67-56-1

RTECS: PC1400000

OSHA PEL S,200PPM/250STEL

ACGIH TLV: S,200PPM/250STEL; 93

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

(ORAL,RAT)

CAS: 75-09-2

RTECS: PA8050000

OSHA PEL 500 PPM; 1000, C

ACGIH TLV: 50 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

(ORAL,RAT) 5.200 MG/KG.

CAS: 1330-20-7

RTECS: ZE2100000

OSHA PEL 100 PPM;150 PPM STEL

ACGIH TLV: 100 PPM;150 PPM STEL

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

USES IN HUMANS ACUTELY OR CHRONICALLY EXPOSED TO

RTECS: 9999999ZZ

TO PREVENT ASPIRATION OF LIQUID INTO LUNGS.

RTECS: 9999999ZZ

FOR DISPOSAL. DO NOT FLUSH TO SEWER.

RTECS: 9999999ZZ

LD50 LC50 Mixture:SEE INGREDIENTS.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:(ACUTE)CAN LEAD TO CNS DEPRESS W/EFTS
OF HDCH, DIZZ, NAUS, & LOSS OF CONSCIOUSNESS. EYE IRRIT. DEFATS
SKIN WHICH CAN LEAD TO IRRIT. INHAL MAY BE SLIGHTLY IRRIT TO MUC
MEMB. INGEST MAY RSLT IN VOMIT. A SPIR MUST BE AVOIDED TO AVOID
PNEUM. (CHRONIC) MARKED IRRIT OF SKIN & EYE UPON CHRONIC OVEREXP AS
WELL (EFTS OF OVEREXP)
Explanation of Carcinogenicity:ING 2: IARC GROUP 2B, NTP ANTICIPATED TO
BE A CARCINOGEN, ACGIH GRP A2.
Effects of Overexposure:HLTH HAZ:AS LIVER & KIDNEY DMG. TARGET ORGANS:
LIVER & KIDNEY. SYSTEMIC & OTHER EFTS: EXCESSIVE EXPOS MAY CAUSE
CNS, LIVER/KIDNEY EFTS. METHYLENE CHLORIDE HAS BEEN SHOWN TO INCR
RATE OF SPONT OCCURING MALIGNANT TUMORS IN 1 STRAIN OF LAB MOUSE &
BENIGN TUMORS IN LAB RATS. OTHER TUMORIGENIC RESPONSE RELATABLE TO
(SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:INHAL: REMOVE VICTIM TO FRESH AIR & PROVIDE O2 IF BRTHG IS
DFCLT.GIVE ARTF RESP IF NOT BRTHG. GET MED ATTN. EYE: FLUSH WITH
WATER FOR AT LEAST 15 MIN WHILE HOLDING EYELIDS OPEN. GET MED ATTN.
SKIN: WA SH W/SOAP & H2O. REMOVE CONTAM CLTHG & SHOES;DO NOT REUSE
UNTIL CLEANED. IF PERSISTENT IRRIT OCCURS, GET MED ATTN. INGEST: DO
NOT INDUCE VOMIT. IF VOMIT OCCURS SPONT, KEEP HEAT BELOW HIPS (ING
5)

Flash Point Method:TCC
Flash Point:81.0F,27.2C
Extinguishing Media:"ALCOHOL" FOAM CO2, DRY CHEMICAL, WATER SPRAY.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED PRESSURE DEMAND SCBA
AND FULL PROT EQUIPMENT . EVACUATE HAZARD AREA OF UNPROTECTED
PERSONNEL. COOL FIRE-EXPOS CNTNRS W/WATER.
Unusual Fire/Explosion Hazard:VAPS ARE HVR/AIR & MAY ACCUMULATE IN LOW
AREAS/AREAS INADEQUATELY VENT. VAPS MAY ALSO TRAVEL ALONG GROUND TO
BE IGNITED AT LOCATIONS DISTANT FROM HNDLG (SUPDAT)

Spill Release Procedures:ELIMINATE ALL SOURCES OF IGNITION. SML SPILLS:
TAKE UP W/ABSORB & PLACE IN LBLD CNTNR FOR DISP. LRG SPILLS: EVAC
AREA OF UNPROTECTED PERS. STOP LEAK & CONTAIN SPILL. REMOVE VIA
VACUUM TRUCKS. TAKE UP REMAINDER W/ABSORB & PLACE IN LBLD CNTNR
(ING 6)
Neutralizing Agent:NOT APPLICABLE.

Handling and Storage Precautions:INDOOR/OUTDOOR STORAGE AT 32-120F.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. READ ENTIRE LABEL
BEFORE USING. NO SMOKING IN AREA OF USE. DO NOT USE IN GEN VICINITY
OF ARC WELDING, OPEN FLAMES/HOT SURFACES. HEAT &/OR UV RADIATION
MAY CAUSE FORM OF HCL AND/OR PHOSGENE .

Respiratory Protection:TYPICAL USE DOES NOT REQUIRE RESPIRATORS.
HOWEVER, IN EMERGENCY SITUATIONS WHERE EXPOSURE EXCEEDS OSHA
STANDARDS: 500 PPM/ NIOSH/MSHA SUPPLIED AIR W/FULL FACE
PIECE/NIOSH/MSHA SCBA W/FULL FACEPIECE.
Ventilation:GENERAL EXHAUST IS ADEQUATE UNDER NORMAL CIRCUMSTANCES.
Protective Gloves:PVA GLOVES.
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:SHOES OR BOOTS.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EXPLO HAZ: SITE. THERM DECOMP PRODS MAY INCL HCL & PHOSGENE . EFTS OF
OVEREXP: METHYLENE CHLORIDE. CHLOROCARBON MATLS HAVE PRODUCED
SENSIT OF MYOCARDIUM TO EPINEPHRINE IN LAB ANIMALS & COULD HAV E
SIMILAR EFT IN HUMANS. ADRENOMIMETICS(E.G., EPINEPHRINE) MAY BE
CONTRAINDICATED EXCEPT FOR LIFE-SUSTAINING (ING 4)

HCC:V3
Spec Gravity:.925 (H2O=1)
Evaporation Rate & Reference:>1 (BUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:TRANSPARENT, COLORLESS, PETROLEUM ODOR.

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:OPEN FLAME.
Hazardous Decomposition Products:CO. HCL, PHOSGENE .

Waste Disposal Methods:PLACE IN DISPOSAL FACILITY APPROVED UNDER RCRA
REGULATIONS FOR HAZARDOUS WASTE. USE NON-LEAKING CONTAINERS, SEAL
TIGHTLY AND LABEL PROPERLY. DISPOSE OF IN ACCORDANCE WITH FEDERAL,
STATE AND LOCAL REGU LATIONS .

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.